001 发动机装置Engine Assembly

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 6BT5.9-C125 发动机(SO12038) Diesel Engine 1
2 Z33E0101T6 燃油箱 Fuel Tank 1
3 Z33E0102T6 冷却系统 Cooling System 1
4 Z33E0103T6 进水胶管 Inlet Hose 4
5 Z33E0104T6 出水胶管 Outlet Hose 1
6 Z33E0105T6 风扇支架 Fan Support 1
7 5732 卡箍φ38～φ63 Clamp 2
8 5744 卡箍φ57-φ82 Clamp 2
9 Z33E0106T6 排气系统 exhaust Assembly 1
10 Z33E0107T6 进气系统 Admission Assembly 1
11 Z33E0108T6 传动轴总成 Transmission Shaft 1
12 CG933-ST2100 熄火拉丝 Choke 1
13 Z33E0109T6 油门操纵阀 Pedal Control Valve 1
14 1308010-432-CG20 风扇 Fan 1
15 Z33E0115T18 发动机左前支架 Engine bracket 2
16 Z33E0116T18 发动机右前支架 Engine bracket 1
17 Z33E0111T6 发动机支架2 Engine bracket 1
18 Z33E0112T6 发动机支架3 Engine bracket
19 E300 减震器 Pamper 2
20 E220 减震器 Pamper 2
21 Z33E0113T6 进油管总成 In-vitta 1
22 Z33E0114T6 燃油管M14×1200×M12 Out- vitta 1
23 Z3BII010000006 油压接头 Tie-In 1
24 ZL30B.1.1-4 大接头螺栓 Bolt 2
25 Z50G010000001T7 取暖回水接头 Tie_Out Warm Water Pipe 1
26 Z33E010000001T7 垫板 Board 2
27 LHCI-17 管卡 Nozzle 4
28 LHCI-8 管卡 Nozzle 2
B1 GB/T 5783-2000 螺栓M27X65 Bolt M27X65 4
B2 GB/T 93-1987 垫圈27 Washer 27 4
B3 GB/T 5783-2000 螺栓M16X80 Bolt M16X80 12
B4 GB/T 93-1987 垫圈16 Washer16 17
B5 GB/T96.1-2002 垫圈16 Washer16 17
B6 GB/T 6170-2000 螺母M16 Nut M16 12
B7 GB/T 5783-2000 螺栓M16X40 Bolt M16X40 3
B8 JB/T982-1977 垫圈14 Washer 14 4
B9 GB/T 5783-2000 螺栓M12×35×1.75 Bolt M16X35 14
B9 GB/T 93-1987 垫圈12 Washer 12 18
B10 GB/T 5783-2000 螺栓M10X16 Bolt M10X16 2
B11 GB/T 93-1987 垫圈10 Washer 10 2
B12 GB/T 5783-2000 螺栓M12X30 Bolt M12X30 4
B13 GB/T 6170-2000 螺母M12 Nut M12 4
B14 GB/T 93-1987 垫圈12 Washer12 4
B15 GB/T 5783-2000 螺栓M16X50 Bolt M16X50 2

002 Z33E0101T6 燃油箱 Fuel Tank

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z33E010101T6 燃油箱体 Tank Body 1
2 Z33E010104T6 加油管 Gas pipe 1
3 4H-33 螺塞 Threaded Plug 1
4 CG50.1.1-2 法兰盘 Flange 1
5 Z33E010102 吸油管总成 Suck Fuel Tube Assembly 1
B1 GB/T 5783-2000 螺栓 M8×25 Bolt M8×25 18
B2 GB/T 93-1987 垫圈8 Washer 8 18
B3 GB/T 96.1-2002 垫圈8 Washer 8 6
B4 GB/T 70.1-2000 螺钉M5X20 Bolt M5×20 4
B5 GB/T 93-1987 垫圈 5 Washer 5 4
B6 GB/T 3452.1-2000 O形圈 80×5.3 O-Ring 80×5.3 1
B7 GB/T 3452.1-2000 O形圈 132×5.3 O-Ring 132×5.3 2
B8 GB/T 3452.1-2000 O形圈 60×2.65 O-Ring 60×2.65 1

003 Z33E0102T6 冷却系统 Cooling System

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 CG932H-000b 水箱总成 Radiator Assembly 1 扬州三叶
2 变矩器油散 Torque Converter Radiator 1 扬州三叶
3 液压油散 Hydraulic Oil Radiator 1 扬州三叶
4 橡胶垫板 Rubber 2 扬州三叶
5 Z33E010200001T7 底板 Board 1
6 Z33E010200002T7 压板 Board 1
7 Z33E010200003T7 橡胶板 Rubber 1
8 风扇保护罩 Fan protect 1
9 LHCI-20 管夹 Clamp 2
10 LHCI-13 管夹 Clamp 5
11 Z33E010200001T6 橡胶管φ8 Hosepipeφ8 0.8m
12 5706 卡箍φ10～φ22 Clamp 2
13 Z33E010200002T6 橡胶管φ21 Hosepipeφ21 1.5m
14 5712 卡箍φ13～φ32 Clamp 2
B1 GB/T 97.2-2002 垫圈8 Washer 8 10
B2 GB/T 5783-2000 螺栓M8X16 Bolt M8X16 7
B3 GB/T 93-1987 垫圈8 Washer 8 12
B4 GB/T 5783-2000 螺栓M12X35 Bolt M12X35 4
B5 GB/T 93-1987 垫圈12 Washer 12 4
B6 GB/T 96.1-2002 垫圈12 Washer 12 4
B7 GB/T 5783-2000 螺栓M8X30 Bolt M8X30 5
B8 GB/T 6170-2000 螺母 M8 Nut M8 5

004 Z33E0106T6 排气装置 Exhaust Assembly

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 XH.G664X.W 消声器 Muffler 1
2 Z33E010600001T6 垫板 Cushion 1
3 Z33E010601T6 消声器支架 Muffler Support 1
4 Z33E010600002T6 垫板 Cushion 1
B1 GB/T5783-2000 螺栓M10×35 Bolt M10X35 18
B2 GB/T93-1987 垫圈10 Washer 10 18
B3 GB/T97.1-2002 垫圈10 Washer 10 18
B4 GB/T6170-2000 螺母M10 NutM10 14

005 Z33E0107T6 进气系统 Admission Assembly

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 A030A154 空气滤清器 Air Cleaner 1
2 Z33E010701T6 空滤器支架组件 Air Cleaner Bracket Assembly 2
3 Z33E010700001T6 支架板3 Bracket3 2
4 Z33E010700002T6 隔热板 heat insulation board 1
5 5716 卡箍φ25～φ51 Clamp 2
6 5772 卡箍φ76～φ127 Clamp 2
7 Z33E010700003T6 进气胶管 Inlet Gas Colloid Pipe 1
8 LHCI-32 管夹 Clamp 2
9 Z33E010700004T6 空压泵进气管φ25 Air pump Inlet Gas pipe φ25 2m
B1 GB/T5783-2000 螺栓M10×30 Bolt M10X30 5
B2 GB/T93-1987 垫圈10 Washer 10 9
B3 GB/T6170-2000 螺母M10 NutM10 5

006 33E0108T6 传动轴总成 Transmission Shaft

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z33E010601 联接凸缘 Flange 1
2 Z3BII010403 联轴节 Cardo 1
3 Z3BV010401 传动轴 Shaft 1
4 Z3BII010400001 垫圈 Washer 12
5 Z3BII010400002 联接端盖 Cover 1
6 Z3BII010400003 锁紧钢丝 Locknut 1
B1 DTF-CO 螺母M16×1.5 NutM16×1.5 6
B2 GB/T91-2000 销4×35 pin4×35 9
B3 GB/T93-1987 垫圈16 Washer 16 17
B4 GB/T31.3-1988 螺栓M16×1.5×70 Bolt M16X1.5X70 3
B5 GB/T31.3-1988 螺栓M16×1.5×90 Bolt M16X1.5X80 3
B6 GB/T31.3-1988 螺栓M16×1.5×X90 Bolt M16X1.5X90 3
B7 GB/T 5783-2000 螺栓M16X1.5X45 Bolt M16X1.5X45 8

007 Z33E0109T6 油门操作装置 Pedal Control Valve

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark

1 CG（A）-1129001 油门操纵阀 Accelerograph Control Valve 1
2 30E2300 软轴总成 Cable Assembly 1
3 Z33E010500001T7 油门支架 Bracket 1
4 Z33E010500002T7 软轴支架 Inlet Gas Colloid Pipe 2
6 螺母 Nut 3 油门操纵阀自带
7 垫圈 Washer 3 油门操纵阀自带
螺栓 Bolt 3 油门操纵阀自带
螺母 Nut 2 油门操纵阀自带
8 LHCI-10 管夹 Clamp 2
B1 GB/T5783-2000 螺栓M6×12 Bolt M6X12 2
B2 GB/T93-1987 垫圈6 Washer6 2
B3 GB/T6170-2000 螺母M6 NutM6 2
B4 GB/T5783-2000 螺栓M10×16 Bolt M10X40 2

008 变矩器Torque Converter

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z3BⅡ020000003 驱动轴 Shaft-Drive 1
2 GB1235-76 O型密封圈95X3.1 O-Ring Seal 95X3.1 1
3 GB276-94 轴承6210 Bearing 6210 2
4 Z3BⅡ020000002 罩轮 Converter Drive Housing 1
5 Z3BⅡ020100003 一级涡轮罩 Ist Turbine Housing 1
6 Z3BⅡ020100001 一级涡轮鼓 Ist Turbine Hub 1
7 GB893.1-86 挡圈 52 Snap Ring 52 1
8 NSK 轴承 6013 Bearing 6013 1
9 Z3BⅡ0202 二级涡轮 2nd Turbine 1
10 Z3BⅡ020100005 一级涡轮 1nd Turbine 1
11 GB894.1-86 挡圈 50 Snap Ring 50 1
12 GB5783-86 螺栓 M10X25 Bolt M10X25 8
13 GB93-87 垫圈10 Washer 10 17
14 GB119-96 销 A10X22 Pin A10X22 1
15 GB6170-86 螺母 M8 Nut M8 25
16 GB93-87 垫圈 8 Washer 8 32
17 Z3BⅡ020100004 弹性销 Stretch Pin 9
18 GB869-86 铆钉 8X18 Rivet 8X18 12
20 Z3BⅡ020000012 挡圈 Snap Ring 1
22 Z3BⅡ020000010 导向轮 Stator 1
23 Z3BⅡ020000013 导油环 Oil Catch Ring 1
24 Z3BⅡ020000017 铁丝(d=1.2毫米) Locking Wire 按需
25 Z3BⅡ020000028 螺栓 M8X30 Bolt M8X30 12
26 Z3BⅡ020000019 压紧垫片 Gasket 4
27 Z3BⅡ020000018 调整垫片 Adjusting Shim 12
28 Z3BⅡ020000009 泵轮 Impeller 1
29 GB848-85 垫圈 8 Washer 8 24
30 GB5783-86 螺栓 M8X40 Bolt M8X40 24
31 GB276-94 轴承6017 Bearing 6017 2
32 Z3BⅡ020000027 齿轮 Gear 1
33 Z3BⅡ020000016 密封环 Seal Ring 1
34 Z3BⅡ020000015 导轮座 Stator Seat 1
35 Z3BⅡ020000029 螺栓 M10X25 Bolt M10X25 9
36 YJSW315.6A-9 密封环106.2X3 Seal Ring 106.2X3 1
37 YJSW315.6A-26 O形密封圈 O-Ring Seal 1

009 Z3BⅡ02 变矩器（二） Torque Converter（Ⅱ）

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 GB898-88 双头螺柱 M14X35 Stud M14X35 4
2 GB93-87 垫圈 14 Washer 14 8
3 GB5783-86 螺栓 M14X80 Bolt M14X80 4
4 Z3BⅡ0312 变速箱支架 Transmission Bracket 2
5 Z3BⅡ030100066 调整垫片 Adjusting Shim 2组
6 GB97.1-86 垫圈 14 Washer 14 8
7 GB6170-86 螺母M14 Nut M14 8
8 HG4-692-67 油封 65X90X12 Oil Seal 65X90X12 1
9 GB893.1-86 挡圈 90 Snap Ring 90 2
10 GB5781-86 螺栓 M10X30 Bolt M10X30 12
11 GB93-87 垫圈 10 Washer 10 12
12 Z3BⅡ020000001 端盖 End Cover 1
13 Z3BⅡ020000006 垫 Paper Gasket 1
14 Z3BⅡ020000004 垫圈 Washer 2
15 Z3BⅡ020000005 接头 Connector 2
16 Z3BⅡ020000014 壳体 Housing 1
17 Z3BⅡ020100007 垫 Paper Gasket 1
18 Z3BⅡ020000008 垫板 Plate 1
19 GB93-87 垫圈 8 Washer 8 8
20 GB5783-86 螺栓 M8X16 Bolt M8X16 8
21 Z3BⅡ020000024 垫片 Washer 2
22 Z3BⅡ020000026 弹簧 Spring 1
23 Z3BⅡ020000022 阀杆 Valve Rod 1
24 Z3BⅡ020000020 阀盖 Valve Cover 1
25 Z3BⅡ020000023 弹簧 Spring 1
26 Z3BⅡ020000025 阀杆 Valve Rod 1
27 Z3BⅡ020000021 垫板 Plate 1
29 KCLH-30-12-270 直接接头 Connector 1 GM12C
31 1CH-30-27 接头体 22/M27X2 Union 22/M27X2 2

010 变速箱 Transmission

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z33E0301T7 同步齿箱 Combining Gear Set 1
一倒档主动摩擦
2 Z3BⅡ0302 片 DrivingDisk-1st Reverse 8
3 Z3BⅡ0303 倒档行星排 Reverse-Range Plate 1
摩擦片隔离架总
4 Z3BⅡ0304 成 1
5 Z3BⅡ0305 一档行星排 Friction Disks Assmebly 1st-Range Plate 1
6 Z3BⅡ0306 一档齿圈总成 1st-Range Gear Assembly 1
2st-Range
7 Z3BⅡ0307 二档油缸总成 Cylinder Assembly 1
8 Z3BⅡ0308 二档主动摩擦片 Driving Disk-2nd Forward 3
9 Z33E0303 手制动总成 Handle-brake Assembly 1
11 Z3BⅡ0311 二档主动齿轮 Driving Gear-2nd Forward 1
12 Z3BⅡ0312 变速箱支架 Bracket 2
13 Z33E0302T7 吸油管总成 Suction Line Assembly 1
14 Z3BⅡ0314 滤油器 Filter 1
15 Z33E0303T7 加油管总成 Filler Pipe Assembly 1
16 Z3BⅡ030000001 O 形密封圈 O—Ring Seal 1
17 Z3BⅡ030000002 太阳轮 Sun Gear 1
18 Z3BⅡ030000003 调整垫片 Adjusting Shim 1组
19 Z3BⅡ030000004 内密封圈 Internal Seal Ring 1
20 Z3BⅡ030000005 倒档活塞 Piston-Reverse 1
21 Z3BⅡ030000006 外密封圈 External Seal Ring 2
22 Z3BⅡ030000007 一倒档活塞回位弹簧 Return Spring 1st Reverst Piston 16
23 Z3BⅡ030000008 弹簧导杆 Spring Guide Rod 16
24 Z3BⅡ030000009 倒档一档从动片 Driven Plate-1st Reverse 8
25 Z3BⅡ030000010 隔圈 Spacer 1
26 Z33E030000002T7 变速箱壳体 Transmission Housing 1
27 Z3BⅡ030000012 一档活塞 Piston-1st Forward 1
28 Z3BⅡ030000013 内密封圈 Internal Seal Ring 1
29 Z3BⅡ030000014 一档油缸 Cylinder-1st Forward 1
30 Z3BⅡ030000001T37 大齿轮 Gear 1
31 Z3BⅡ030000016 二档齿圈 Ring Gear -1st Forward 1
二档活塞回位弹
32 Z3BⅡ030000017 簧 Piston-1st Forward 12
33 Z3BⅡ030000018 外密封圈 External Seal Ring 1
34 Z3BⅡ030000019 二档活塞 Piston-2nd Forward 1
35 Z3BⅡ030000020 右盖 Right Cover 1
锁紧铁丝φ
36 Z3BⅡ030000021 1.5X600 Tighten Iron 1
37 Z3BⅡ030000022 配油套 Oil Sleeve 1
38 Z3BⅡ030000023 轴盖 Shaft Cover 1
39 Z3BⅡ030000024 后输入轴 Input Shaft -Rear 1
40 Z3BⅡ030000025 内密封圈 Internal Seal Ring 1
41 Z3BⅡ030000026 油孔螺塞 Thread Plug 1
42 Z3BⅡ030000027 二档从动片 Driven Plate-2nd Forward 3
44 Z3BⅡ030000029 右压盖 Right Cover 1
45 Z3BⅡ030000030 连接凸缘 Flange 2
46 Z3BⅡ030000031 前输出轴 Output Shaft—Front 1
47 Z33E030000002 制动盘 Brake Plate 1
48 Z3BⅡ030000033 调整垫片 Adjusting Shim 1组
49 Z3BⅡ030000034 隔离套 Spacer 1
50 Z3BⅡ030000002T37 被动齿轮 Driven Gear 1
51 Z33E030000001T7 法兰盘 Flange 1
52 Z3BⅡ030000037 支承套 Sleeve 1
53 Z3BⅡ030000038a 挡板 Plate 1
55 Z3BⅡ030000040a 磁铁 Magnet 1
56 Z3BⅡ030000041 滑动轴套 Bushing 1
57 Z3BⅡ030000042 滑套 Sliding Sleeve 1
58 Z3BⅡ030000043 定位弹簧 Locating Spring 1
59 Z3BⅡ030000044 后输出轴 Output Shaft Rear 1
60 Z3BⅡ030000045 纸垫 Paper Gasket 1组
61 Z3BⅡ030000046 左压盖 Left Cover 1
62 Z3BⅡ030000047 防尘罩 Dust Shroud 1
63 Z3BⅡ030000048 隔圈 Spacer 1
64 Z33E030000004 防尘罩 Dust Shroud 1
67 Z3BⅡ030000052 压圈 Clamping Ring 1
72 Z3BⅡ030000057 定位螺钉 Set Screw 1
73 Z3BⅡ030000058 销轴盖 Pin End Cover 1
74 Z3BⅡ030000059 定位销 Plunger 1
75
76 Z3BⅡ030000061 拨叉 Shift Fork 1
77 Z3BⅡ030000062 拨叉轴 Shaft—Shift Fork 1
78 Z3BⅡ030000063 油封衬套 Lining—Oil Sea 1
79 Z3BⅡ030000064 前输入轴 Input Shaft Front 1
80 Z3BⅡ030000065 键 Key 2
81 Z3BⅡ030000066 调整垫 Adjusting Shim 2组
82 Z3BⅡ030000067 O 形密封圈 52X3.5 O—Ring Seal 52x3.5 1
83 4HN-22 螺塞 M22X1.5 Thread Plug M22X1.5 1
84 Z30030000006 盖板 Cover 1
85 Z3BⅡ030000069 底板 Plate 1
86 Z3BⅡ030000070 密封垫 Seal Gasket 1
87 GB/T5783-2000 螺栓 M12X35 Bolt M12×35 18
88 GB/T93-87 垫圈 12 Washer 12 30
89 GB/T32.1-88 螺栓 M10X65 Bolt M10×65 8
90 GB/T97.1-2002 垫圈 10 Washer 10 8
91 GB/T276-94 轴承 6020 Bearing 6020 1
92 GB/T894.1-86 挡圈 45 Snap Ring 45 2
93 GB/T5783-2000 螺栓 M8X20 Bolt M8×20 8
94 GB/T93-87 垫圈 8 Washer 8 23
95 GB/T276-94 轴承 6004 Bearing 6004 1
96 GB/T5783-2000 螺栓 M8X35 Bolt M8×35 18
97 GB/T5783-2000 螺栓 M10X30 Bolt M10×30 8
98 GB/T93-87 垫圈 10 Washer 10 14
99 HG4-692-67 油封 SG70X100X13 Oil Seal SG70×100×13 1
102 GB/T276-94 轴承 6213 Bearing 6213 1
103 GB/T276-94 轴承 6211 Bearing 6211 1
104 Z3BⅡ030000039 挡圈 55 Snap Ring 55 1
105 GB/T5783-2000 螺栓 M6X25 Bolt M6×25 3
106 GB/T93-87 垫圈 6 Washer 6 3
107 GB/T308-2000 钢球 10 Ball 10 2
108 GB/T893.1-86 挡圈 150 Snap Ring 150 1
109 GB/T93-87 垫圈 14 Snap Ring 14 8
110 GB/T6170-2000 螺母 M14 Nut M14 12
111 GB/T276-94 轴承 6309 Bearing 6309 1
112 GB/T59-76 螺母 M27X1.5 Nut M27X1.5 2
113 GB/T91-86 销 5X50 Pin 5X50 2
114 GB/T97.1-2002 垫圈 27 Washer 27 4
115 HG4-692-67 油封 SG60X90X12 Oil Seal SG 60×90×12 1
116 GB/T893.1-86 挡圈 100 Snap Ring 100 1
117 GB/T5783-2000 螺栓 M10X25 Bolt M10×25 6
118 GB/T5783-2000 螺栓 M14X80 Bolt M14×80 4
119 GB/T1235-76 O 形密封圈16X2.4 O—Ring Seal 16X24 1
120 GB/T95-2002 垫圈 8 Washer 8 18
121 GB/T901-88 双头螺栓 M8X35 Stud BM8×35 1
122 GB/T893.1-86 挡圈 120 Snap Ring 120 1
123 GB/T5783-2000 螺栓 M14X65 Bolt M14×65 4
124 GB/T97.2-2002 垫圈 14 Washer 14 4
125 GB/T5783-2000 螺栓 M12X30 Bolt M12×30 8
126 GB/T1235-76 O 形密封圈125X5.7 O—Ring Seal 125X5.7 1
127 GB/T1235-76 O 形密封圈22X2.4 O—Ring Seal 22X2.4 1
128 GB/T6170-2000 螺母 M8 Nut M8 1
129 GB/T97.1-2002 垫圈 14 Washer 14 8
130 GB/T1235-76 O 形密封圈85X5.7 O—Ring Seal 85X5.7 1
131 Z33E030000003 调整垫 Adjusting Shim 1组
132 Q/CG302.11-95 垫圈 14 Washer 14 1
133 GB/T898-88 双头螺柱BM14X35 Stud BM14×35 4
134 GB/T5783-2000 螺栓 M8X25 Bolt M8×25 17
135 GB/T5783-2000 螺栓 M12X40 Bolt M12×40 4

011 Z33E0301T7 同步齿箱 Combining Gear Set

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z33E030101T7 齿轮泵 Powe Shift Pump 1
2 ZL30B.3.1.2 超越离合器 Exceed Clutch 1
3
4 ZL30B.3.1.3-6 直角接头 Union 1
5 05C3201 通气塞 Breather 1
6 ZL30B.3.1-1 输入二级齿轮 2nd Input Gear 1
7 ZL30B.3.1-2 输入一级齿轮 1st Input Gear 1
8 ZL30B.3.1-3 二级齿轮油封环 Oil Seal Ring—2nd Gear 1
9 ZL30B.3.1-4 一级齿轮油封环 Oil Seal Ring—1st Gear 1
10 ZL30B.3.1-5A 衬套 Bushing 1
11 ZL30B.3.1-6 隔离套 Spacer 1
12 ZL30B.3.1-7 铜管 Copper Pipe 1
13 Z33E030100001T7 箱体 Housing 1
14 ZL30B.3.1-9 密封垫片 Gasket 1
15 ZL30B.3.1-10A 油泵轴 Shaft—Oil Pump 1
16 ZL30B.3.1-11 中间隔套 Spacer 1
17 ZL30B.3.1-12 阀罩 Valve Cover 1
18 ZL30B.3.1-13 调整螺钉 Adjusting Screw 1
19 ZL30B.3.1-14 螺母 Nut 2
20 ZL30B.3.1-15 垫圈 Gasket 1
21 ZL30B.3.1-16 弹簧 Spring 1
23 ZL30B.3.1-18 管卡 Clip 1
24 ZL30B.3.1-19 阀 Valve 1
26 ZL30B.3.1-21A 转向油泵轴 Shaft—Steering Pump 1
27 Z33E030100002T7 转向泵连接法兰 Flange—Steering Pump 1
28 Z33E030100003T7 挡油板 Protective Sheet 1
29 ZL30B.3.1-24 齿轮 Gear 2
30 ZL30B.3.1-25 隔套 Spacer 2
31 GB/T3452.1-2005 O形圈103X3.55 O —Ring Seal103X3.55 1
32 GB/T3452.1-2005 O形圈92.5X3.55 O —Ring Seal92.5X3.55 1
33 GB/T5783-2000 螺栓 M10×30 Bolt M10×30 18
34 GB/T93-87 垫圈 10 Washer 10 27
35 GB/T276-94 轴承 6210 Bearing 6210 1
36 GB/T276-94 轴承 6308 Bearing 6308 2
37 GB/T276-94 轴承 6016 Bearing 6016 1
38 GB/T301-95 轴承51111 Bearing 51111 1
39 GB/T276-94 轴承 6208 Bearing 6208 1
40 GB/T6170-86 螺母 M12 Nut M12 2
41 GB/T93-87 垫圈 12 Washer 12 2
42 GB/T5783-2000 螺栓 M14×45 Bolt M14×45 2
43 GB/T276-94 轴承 6012 Bearing 6012 1
44 GB/T276-94 轴承 6309 Bearing 6309 1
45 GB/T893.1-86 挡圈 75 Snap Ring 75 2
46 GB/T276-94 轴承 6309 Bearing 6309 1
47 GB/T70.1-2000 螺钉M10X30 Screw M10×30 4
48 GB/T276-94 轴承 6010 Bearing 6010 1
49 GB/T5783-2000 螺栓 M6×10 Bolt M6×10 3
50 GB/T93-87 垫圈 6 Washer 6 1
51 HG4-692-67 油封 60×80×13 Oil Seal 60×80×13 1
52 HG4-692-67 油封 45×65×12 Oil Seal 45×65×12 1
53 GB/T898-88 螺柱 AM12×70 Stud AM12×70 2
54 GB/T5783-2000 螺栓 M10×50 Bolt M10×50 1
55 1CH-30-27 接头体 22/M27×2 Union 22/M27×2 1
56 GB/T93-87 垫圈 14 Washer 14 2
57
58
59
60
61
62
63
64
65
66
67

012 Z33E030101T7 齿轮泵 Powe Shift Pump

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z3BII030101001 轴 Shaft 1
2 Z3BII030101002 小齿轮 Pinion 1
3 Z3BII030101003 大齿轮 Major Gear 1
4 Z3BII030101004 挡圈 Snap Ring 1
5 Z3BII030101005 泵盖 Cover—Pump 1
6 Z3BII030101006 密封垫 Gasket 1
7 Z33E030101001T7 泵体 Pump Body 1
8 Z3BII030101008 挡环 Retaining Ring 1
9 GB/T898-88 螺柱 AM10×50 Stud AM10×50 4
10 GB/T6170-2000 螺母 M10 Nut M10 6
11 GB/T859-87 垫圈 10 Washer 10 8
12 HG4-692-67 油封 45×62×10 Oil Seal 45×62×10 1
13 GB/T893.1-86 挡圈 62 Snap Ring 62 1
14 GB/T70-2000 螺钉M10X75 Screw M10×30 2
15 GB/T117-86 销8X28 Pin8X28 2
16 GB/T898-88 螺柱 AM10×50 Stud AM10×50 4
17 1CH-36-33 接头体 28/M33×2 Union 28/M33×2 1
18
19 GB/T309-2000 滚针P4X15.8G2 Needle P4X15.8G2 18

013 ZL30B.3.1.2 超越离合器 Exceed Clutch

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 ZL30B.3.1.2-1 弹簧 Spring 3
2 ZL30B.3.1.2-2 压盖 Cap 1
3 ZL30B.3.1.2-3A 隔离环 Spacer 1
4 ZL30B.3.1.2-4 外环齿轮 Ring Gear—External 1
5 ZL30B.3.1.2-5 内环齿轮 Internal Ring cam 1
6 ZL30B.3.1.2-6 挡环 Retaining Ring 1
7 ZL30B.3.1.2-7 滚柱 Roller 16
8 ZL30B.3.1.2-8 中间输入轴齿轮 Gear—Middle Input 1
9 ZL30B.3.1.2-9 螺栓 Bolt 16
10 GB/T91-86 销 2×16 Pin 2×16 16
11 GB/T9457-88 螺母 M8×1 Nut M8×1 16
12
13
14
15
16
17
18
19

014 Z3BⅡ0302 一倒档主动摩擦片 DrivingDisk-1st Reverse

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z3BⅡ030200001 主动片 Driving Plate 1
2 Z3BⅡ030200002 摩擦片 Disk 2

015 Z3BⅡ0303 倒档行星排 Reverse-Range Plate

序号代号名称数量备注
Item Part No. Parts Name Q'ty Remark
1 Z3BⅡ03030002 倒档行星架 Planetary Carrier-Reverse 1
2 Z3BⅡ03030001 行星轮 Planetary Gear 4
3 Z3BⅡ03030006 垫片 Gasket 8
4 GB/T309-2000 滚针P3.5X19.8G2 Needle P3.5X19.8G2 100
5 Z3BⅡ03030007 挡圈 Snap Ring 8
6 GB/T32.1-88 螺栓M8X16 Bolt M8X16 4
7 Z3BⅡ03030005 销圈 Pin Ring 4
8 Z3BⅡ03030003 倒档行星轴 Planetary Shaft-Reverse 4
9 GB/T276-94 轴承 6010 Bearing 6010 1
10 GB/T893.1-86 挡圈 80 Snap Ring 80 1
11 Z3BⅡ03030004 销紧铁丝 Tighten Iron 1