Back to Main Page:
Dongfeng Cummins Engine 6BT5.9-G1 Parts Catalog Main Page
021 SZ1520A 座椅 Seat -- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 座椅 ZL15G 带扶手,安全 Seat 1 whatsapp 86-18630852087
2 GB5782-86 螺栓 M10×30 Bolt 4
3 GB93-87 垫圈 10 Washer 4 whatsapp 86-18630852087
022 SZE1521C 发动机罩 Engine Cover -- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 机罩体 Engine Cover 1 whatsapp 86-18630852087
2 左门 Left Door 1
3 右门 Right Door 1
4 后窗 Rear Window 1 whatsapp 86-18630852087
5 GB5782-86 螺栓 M16×30 Blot 8
6 GB95-85 垫圈 16 Washer 8
7 GB93-87 垫圈 16 Washer 8 whatsapp 86-18630852087
023 SZB1523 电气系统 Electrical System -- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 SZB1523-0-2 管φ25*2.5*13 Pipe 1 whatsapp 86-18630852087
2 991000017 顶灯 NZ1-1,24V Top Lamp 1
3 SZB1523-15 仪表台 Instrument Board 1
4 WD120*120-1 前照灯 Front Lamp 4
5 SZB1523-0-1 连接板 Joint Board 1
6 9912000154 蜂鸣器 Buzzer 1
7 XH8-4 组合后灯 Composite Back Light 2
8 电缆 1.8m QVR50mm2 Cable 1
9 电缆 1.6m QVR50mm2 Cable 1 witch whatsapp 86-18630852087
11 电瓶卡子"-" Battery Clip 2
12 6-QA-90 蓄电池 Battery 2
13 电缆 2m QVR50mm2 Cable 1
14 991302003 尼龙扎带 50D91-1 Nylon Band 5
15 991302002 尼龙扎带 30D91-1 Nylon Band 10
16 991302003 尼龙扎带 16D91-1 Nylon Band 30
17 991302002 尼龙扎带 90D91-1 Nylon Band 2
18 980208070 螺栓 M8*40 (GB5782-86) Bolt 2
19 SZB1523-20 连接板 Joint Board 1
20 990800025 电源开关 JK861 Battery S
21 DL127 24V 喇叭 Speaker 1
22 JK613B 倒车开关 Back Vehicle switch 1
23 SZD3023-4 后灯线束 Back Work Light Wiring Harness 1
24 980706061 螺钉 M6*12 (GB67-85) Screw 10
25 981603906 垫圈 6 (GB97.2-86) Washer 12
26 980706063 螺钉 M6*20 (GB67-85) Screw 10
27 SZ1623-0-4A 尾灯板 Back Light Board 2
28 SZB1523-2 车架线束 Vehicle Wiring Harness 1
29 981200106 螺母 M6 (GB41-86) Nut 2
30 981600106 垫圈 6 (GB93-87) Washer 12
31 SZ1623-0-7 弯板 Bend board 1
32 SZB1523-5 前灯线束 Front Light Wiring Harness 1
33 981603908 垫圈 8 (GB97.2-86) Washer 7 whatsapp 86-18630852087
34 981600108 垫圈 8 (GB93-87) Washer 7
35 980208246 螺栓 M8*25(GB5783-86) Bolt 2
36 HD130-1 前组合灯 Composite Lamp-right 2
37 SZB1523-1 前灯架 Front lamp rack 2
38 ZD2530 刮水器(带开关，雨刷长 400), Window Wiper (With Switch) 1
39 991100002 继电器 JN3A-WX Relay 1
40 981200408 螺母 M8 (GB6170-86) Nut 5
41 981600104 垫圈 4 (GB93-87) Washer 2
42 980704063 螺钉 M4*12 (GB67-85) Screw 4 whatsapp 86-18630852087
024 SZA1524 发动机及其附件 Engine and Attachments -- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 SZA1524-1A 支座总成 Support Assembly 1 whatsapp 86-18630852087
2 SZA1524-0-1 衬套 Cover 2
3 SZB3024-0-8 减振垫 Damping Washer 4
4 SZA1524-0-2 垫 Washer 2
5 SZA1524-2A 下水管 Lower Water Pipe 1
6 SZ1624-0-3 支板 Support Plate 2
7 SZ1624-0-4 橡胶垫 Rubber Washer 2
8 SZ1624-0-2 支杆 Support Pole 2
9 495960000 进油管 Intake Pipe 1
10 495950000 回油管 Returning Pipe 111 SZA1524-5A 上水管 Upper Water Pipe 1
12 1004-4TL11 柴 油 机 雷沃（珀金斯）1004-4TL11 Diesel Engine 1
13 ZL15F(P)-TG 水箱总成 Water Radiator Assembly. 1
14 喉箍 D50-D70 Clip 4
15 GB6170-86 螺母 M12 Nut 2
16 GB93-87 垫圈 12 Washer 13
17 GB96-85 垫圈 12 Washer 4
18 GB5783-86 螺栓 M10*25-8.8 Bolt 11
19 GB5783-86 螺栓 M10*30-8.8 Bolt 14
20 GB93-87 垫圈 10 Washer 14
21 GB97.1-85 垫圈 10 Washer 2 whatsapp 86-18630852087
22 GB28-88 螺栓 M12*100 -8.8 Bolt 2
23 GB6176-86 螺母 M12 Nut 2
24 GB91-86 销 3.2*30 Pin 2
25 GB5785-86 螺栓 M16*2*50-8.8 Bolt 4
26 GB93-87 垫圈 16 Washer 4
27 JB999-77 铰接螺栓 M14*1.5*32 Bolt 2
28 JB982-77 垫圈 14 Washer 4 whatsapp 86-18630852087
025 SZA1525 调速装置 Regulator Device-- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 SZA1525-0-1 软轴支架 Cable Bracket 1 whatsapp 86-18630852087
2 SZA1525-1 脚油门 Throttle Control Value 1
3 GB5783-86 螺栓 M8×30 Blot 3
4 GB93-87 垫圈 8 Washer 3 whatsapp 86-18630852087
5 GB6170-86 螺母 M8 Nut 3
6 GB5783-86 螺栓 M6×25 Blot 2
7 GB93-87 垫圈 6 Washer 2
8 GB6170-86 螺母 M6 Nut 2 whatsapp 86-18630852087
026 .SZ1626 后配重 Rear Additional Weight -- Tiangong Wheel Loader ZL15G Parts Catalog
027 ZL15F.2.5 主减速器总成 -- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 GB/T91-2000 开口销 3.2X40 Pin 1 whatsapp 86-18630852087
2 ZL15F.2.5.1-14 开槽螺母 M20X1.5 Screw 1
3 ZL15F.2.5.1-12 垫圈 Washer 1
4 ZL15F.2.5.1-13 O 型密封圈 36X3.5 O-Ring 1
5 ZL15F.2.5.1-8 输入法兰 Input Flange 1
6 ZL15F.2.5.1-11 防尘罩 Dust-Proof Cap 1
7 ZL15F.2.5.1-10 圆锥主动齿轮油封 Oil Seal 1
8 GB/T5785-2000 螺栓 M12X1.25X45 Bolt 6
9 GB/T93-1997 垫圈 12 Washer 6
10 ZL15F.2.5.1-7D 轴承盖 Bearing Cover 1 11 ZL15F.2.5.1-6 轴承止推垫圈 Washer 1
12 GB/T297-94 滚动轴承 32309 Tapered Roller Bearing 2
13 ZL15F.2.5.1-4 轴承调整垫片 Adjusting Washer Of Bearing 1 组
14 ZL15F.2.5.1-3 轴承隔套 Bearing Cover 1
15 ZL15F.2.5.1-2D 轴承套 Bearing Cover 1
16 ZL15F.2.5-1 调整垫片 Adjusting Plate 1
17 ZL15F.2.5.1-1 主动锥齿轮 Driving Taper Gear 1
18 GB/T283-94 轴承 102205 Bearing 1
19 GB894.1-86 挡圈 25 Circle lip 1 whatsapp 86-18630852087
20 ZL15F.2.5-8A 主减速器壳 Main Case of Differential 1
21 ZL15F.2.5-12 差速器行星齿轮垫 Washer of Planet Gear 4
22 ZL15F.2.5-13 差速器行星齿轮 Planet Gear 4
23 ZL15F.2.5-11A 差速器行星齿轮轴 Planet Gear Shaft 1
24 ZL15F.2.5-14 半轴齿轮 Half Shaft Gear 2
25 ZL15F.2.5-15 半轴齿轮垫片 Washer of Half Shaft Gear 2
26 ZL15F.2.5-10 差速器右壳 Right Case of Differential 1
27 ZL15F.2.5-17 防松垫片 Washer 4
28 ZL15F.2.5-16 差速器壳螺栓 Bolt Of Differential Case 8
29 GB/T297-94 轴承 32210 Tapered Roller Bearing 2
30 ZL15F.2.5-9 调整螺母 Adjusting Nut 2 31 ZL15F.2.5-3 差速器左壳 Left Case of Differential 1
32 ZL15F.2.5-7 从动锥齿轮 Taper Gear 1
33 ZL15F.2.5-4 铆钉 rivet 12
34 ZL15F.2.5-2 差速器轴承盖 Bearing Cover 2
35 ZL80-06.5.2-7 锁片 Locking Plate 4
36 GB/T5785-2000 螺栓 M14X1.5X70 Bolt 4
37 ZL15F.2.5-18 调整螺母锁片 Locking Plate 2
38 GB/T93-1987 垫圈 8 Washer 2
39 GB/T5782-2000 螺栓 M8X18 Bolt 2 whatsapp 86-18630852087
028 钳盘制动器 Disk Brake -- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 ZL15.5-1 外钳 External Clamp 1 whatsapp 86-18630852087
2 408113A 活塞 Piston 2
3 408112 矩形密封圈 Rectangle Seal Ring 2
4 408110 防尘罩 Dust-Proof Cap 2
5 408111 卡圈 Snap Ring 2
6 ZL15.5.1 制动片 Brake Plate 2 whatsapp 86-18630852087
7 GB/T1235-76 O 型圈 20X2.4 O-Ring 2
8 ZL15.5-2 内钳 Internal Clamp 1
9 GB/T93-1987 垫圈 18 Washer 4
10 ZL15.5-3 螺栓 Bolt 4
11 408124 垫圈 Washer 2
12 408104 接头 Joint 2
13 408103 放气嘴 Air Bleeder 2
14 GB/T93-1987 垫圈 10 Washer 2
15 408114 螺栓销 Bolt Pin 2 whatsapp 86-18630852087
029 轮边总成 Wheel Edge Assembly -- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 ZL10.4AB-69 螺塞 M16X1.5 Thread Plug 2 whatsapp 86-18630852087
2 JB982-77 垫圈 16 Washer 2
3 ZL15F.2-6 盖 Cover 2
4 GB/T5782-2000 螺栓 M8X20 Bolt 16
5 GB/T93-1987 垫圈 8 Washer 16
6 ZL15F.2-4 挡销 Circle Pin 2
7 GB/T119-86 销 12X32 Pin 4
8 GB/T5785-2000 螺栓 M12X1.25X35 Bolt 48
9 GB/T93-1987 垫圈 12 Washer 48
10 ZL15F.2.2-4 行星架 Planet Carrier 2
11 ZL15F.2-7 O 型密封圈 305X3.5 O-Ring 2
12 GB894.1-86 挡圈 35 Circle lip 2
13 GB/T309-2000 滚针 3X29.8 Needle 174
14 GB/T308-2002 钢球φ5 Steel Ball 6
15 ZL15F.2.2-2 行星轮轴 Planet Shaft 6
16 ZL15F.2.2-1 行星轮 Planet 6
17 ZL15F.2.2-3 行星轮挡圈 Planet lip 12
18 ZL15F.2-3 半轴 Half Shaft 2
19 ZL15F.2-5 太阳轮 Sun-Gear 2 whatsapp 86-18630852087
20 GB/T70.1-2000 螺钉 M8X16 Screw 2
21 ZL15F.2-20 锁紧螺母 Locking Nut 2
22 ZL15F.2.1-1B 齿圈 Gear ring 2
23 GB/T297-94 轴承 32014 Bearing 2
24 ZL15F.2-17 球螺母 M18X1.5 Ball Nut 16
25 JB982-77 垫圈 24 Washer 2
26 ZL15F.2-14 螺塞 M24X1.5 Thread Plug 2
27 ZL15F.2-8D 外壳 Wheel Hub 2
28 ZL15F.2-16D 轮辋螺栓 Rim Bolt 16
29 GB/T297-94 轴承 32015 Bearing 2
30 GB/T9877.1-88 油封 FB115X140X14 Oil Seal 2 31 ZL15 Ⅱ.03.04.017 制动盘 Brake Disc 2 whatsapp 86-18630852087
030 YJ280 液力变矩器 Hydraulic Torque Converter-- Tiangong Wheel Loader ZL15G Parts Catalog
序号 件 号 名 称 数量
No. PART No. DESCRIPTION QTY
1 YJ280.00-03 副壳体 Ancillary Crust 1 whatsapp 86-18630852087
2 GB5783-86 螺栓 M10×30-10.9 Bolt 18
3 GB93-87 垫圈 10 Washer 26
4 GB5783-86 螺栓 M8×20 Bolt 8
5 GB93-87 垫圈 8 Washer 40
6 YJ280.00-04 防尘板 Dust-proof Plate 2
7 GB9877.2-88 密封圈 FW100×120×12F Seal Washer 1
8 YJ280.00-02 纸垫 Paper Washer 1
9 YJ280.00-14 泵轮齿轮 Turbine Gear 1 whatsapp 86-18630852087
10 GB894.1-86 挡圈 100 Snap Ring 1
11 YJ280.00-18 密封环 80 Seal Ring 2
12 YJ280.03-02 导轮座 Stator Seat 1
13 GB5783-86 螺栓 M8×20-10.9 Bolt 8
14 YJ280.03-01 导轮座衬套 Stator Seat Bush 1
15 YJ280.00-17 涡轮轴 Turbine Axes 1
16 GB276-82 轴承 6308 Bearing 1
17 GB894.1-86 挡圈 90 Snap Ring 1
18 YJ280.00-01 主壳体 Main Crust 1
19 YJ280.00-19 溢流阀垫 Overfull Valve Washer 1
20 YJ265-4000 溢流阀 Overfull Valve 1
21 GB5782-86 螺栓 M10×95-10.9 Bolt 4
22 YJ280.00-16 输出齿轮 Output Gear 1
23 GB894.1-86 挡圈 40 Snap Ring 1
24 GB893.1-86 挡圈 80 Snap Ring 2
25 YJ280.00-11 工作泵轴套 Pump Bush 1 whatsapp 86-18630852087
26 YJ280.00-20 行走泵轴套 Pump Bush 1
27 GB5783-86 螺栓 M10×25-10.9 Bolt 4
28 YJ320 进油阀 Enter Oil Valve 1
29 GB825-88 螺钉 M12 Blot 2
30 GB276-82 轴承 6010E Bearing 5 31 YJ280.00-13 间隔套 Spacing sheath 2
32 YJ280.00-12 油泵齿轮 Pump Bearing 2
33 GB894.1-86 挡圈 50 Snap Ring 3
34 GB119-86 销 8×20 Pin 4
35 YJ280.00-10 泵轮座 Turbine Seat 1
36 GB276-82 轴承 6212E Bearing 1
37 GB893.1-86 挡圈 110 Snap Ring 1
38 GB1235-77 O 形圈 130×3.1 O Ring 1
39 GB5783-86 螺栓 M8×35-10.9 Bolt 24
40 GB97.1-85 垫圈 8 Washer 24
41 YJ280.00-09 泵轮 Pump Pulley 1
42 GB1235-77 O 形圈 290×3.55 O Ring 1
43 YJ280.00-08 导轮 Idler Pulley 1
44 GB894.1-86 挡圈 55 Snap Ring 1
45 GB894.1-86 挡圈 38 Snap Ring 2
46 GB867-86 铆钉 8×24 Rivet 10
47 YJ280.02-03 涡轮毂 Turbine Hub 1
48 YJ280.02-01 涡轮 Turbine 1
49 YJ280.02-02 垫片 Washer 1
50 YJ280.00-07 罩轮 Ring Cover 51 GB6170-86 螺母 M8 Nut 24
52 YJ280.01 弹性板焊合 Flexible Plate Jointing 1
53 YJ280.00-05 弹性板 Flexible Plate 1
54 YJ280.00-06 压圈 Snap Ring 1 whatsapp 86-18630852087
55 GB93-87 垫圈 12 Washer 6
56 GB5783-86 螺栓 M12×25-10.9 Bolt 6 whatsapp 86-18630852087