041 FSJ302 仪表台总成 Cab Plateform Assembly --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备 注
Item Part No． Parts Name Q'ty Remark
1 FSJ302 仪表台总成 Pannel Assembly 1
2 GB93-87 垫圈8 Washer 12 4
3 GB97.1-86 垫圈8 Washer 12 4
4 GB5783-86 螺栓M8X20 Bolt M8X30 4

042 Z50E130103T38 右车门 Right Door --Chenggong Wheel Loader CG935H Parts Catalogue
Z50E130102T38 左车门 Left Door

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark
1 Z50E130103T38 右车门 Right Door 1
2 车门密封条 Seal Strip 1
3 右车门玻璃 Door Glass 1
4 GMS502 左车门锁 Locker 1
5 左车门玻璃 Door Glass 1
6 车门密封条 Seal Strip 1
7 Z50E130102T38 左车门 Door 1

043 Z35H13T13 驾驶室 Cab --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark

1 Z35H1301T13 机棚 Cab Body 1
2 倒车镜 Mirror 2
3 Z50E1304T38 倒车镜支座 Mirror Bracket 2
4 Z50E1306T38 扶手 Handrail 2
5 Z35H130000004T12 座椅支架 Seat Bracket 1
6 CB2205-72 减振器 Absorber 4
7 Z35H130000001 螺栓 Bolt 4
8 Z3BII130000021 锥形垫 Prick Mat 4
9 前窗玻璃 Front Window Glass 1
10 前侧窗玻璃 Front Side Window Glass 2
11 后侧窗胶条 Rear Side Window Rubber Strip 2
12 后窗玻璃 Rear Window Glass 1
13 后窗玻璃胶条 Rear Window Rubber Strip 1
14 GB825-86 吊环螺栓M16X25 Bolt M8X25 4
15 Z50E130100003T10 密封圈 4
16 后侧窗玻璃 Rear Side Window Glass 2
17 GB93-87 垫圈8 Washer 8 16
18 GB97.1-86 垫圈8 Washer 8 16
19 GB5783-86 螺栓M8X20 Bolt M8X20 16

044 CGZY—3H 座椅 Seat --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark

1 CGZY—3H 座椅 Seat 1
B1 GB5781-86 螺栓M8X20 Bolt M8X20 4
B2 GB93-87 垫圈8 Washer 8 4
B3 GB848-85 垫圈8 Washer 8 4

045 Z35F14 工作装置（一） Implement (Ⅰ) --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark

1 Z35F1402 动臂 Arm 1
2 Z30140000005 垫片 Washer 2
3 Z30140000006 轴套 Bushing 2
4 Z301409 销轴 Pin Shaft 2
5 Z30140000007 轴套 Bushing 2
6 Z301410 销轴 Pin Shaft 2
7 Z30140000009 垫片 Washer 2
8 Z30140000008 轴套 Bushing 2
9 Z30140000001 螺栓套 Bushing 6
B1 HG4-692-67 骨架式橡胶油封PD60X80X12 Skeleton Dust Seal Ring PD60X80X12 8
B2 GB5783-86 螺栓 M12X30 Bolt M12X30 4
B3 GB93-87 弹簧垫圈 12 Washer 12 4
B4 HG4-692-67 骨架式橡胶油封PD50X70X12 Skeleton Dust Seal Ring PD50X70X12 4
B5 HG4-692-67 骨架式橡胶油封PD55X75X12 Skeleton Dust Seal Ring PD55X75X12 4
B6 GB1152-89 油杯 M10X1 Oil Cup M10X1 8

046 Z35F14 工作装置（二） Implement ( II ) --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark

1 Z301405 销轴 Pin Shaft 1
2 Z30140000003 轴套 Bushing 2
3 Z301406 销轴 Pin Shaft 1
4 Z30140000004 摇臂 Rocker 1
5 Z30140000002 轴套 Bushing 2
6 Z301408 销轴 Pin Shaft 1
7 Z301407 拉杆 Pull Rod 1
8 Z301404 销轴 Pin Shaft 1
B1 HG4-692-67 骨架式橡胶油封PD80X100X12 Skeleton Dust Seal Ring PD80X100X12 4
B2 GB5783-86 螺栓 M20X35 Bolt M20X35 6
B3 GB1152-89 油杯 M10X1 Oil Cup M10X1 8
B4 HG4-692-67 骨架式橡胶油封PD60X80X12 Skeleton Dust Seal Ring PD60X80X12 8

047 Z35F14 工作装置（三） Implement (III) --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark

1 Z35F1401A 铲斗 Bucket 1
2 Z30140100001 右侧斗齿 Teeth 7
3 Z30140100011 螺栓 Bolt 4
4 Z30141000003 卡环 Clip 8
5 Z30140200001 斗齿体 Bucket Tooth 6
6 Z30140100002 销轴 Pin Shaft 8
7 Z30140100004 齿靴 Boot-Bucket Tooth 8
8 Z30141100001 左侧斗齿体 Teeth 1
9 Z30140100010A 螺栓 Bolt 12
10 Z35F140000001 螺栓 Bolt 14
11 Z35F140000002 可卸防磨板 Assemble Bucket Blade 7
B2 GB6170-86 螺母M20 Nut M20 30

048 Z35H15T13 电气元件 Electrical Element --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark

1 DK231 电源继电器 Battery disconnect relay 1
2 6-QW-120B 蓄电池 Battery 2
3 QD274/6.6KW 起动机 Starting motor 1
4 HG4735 六檔保险盒 Fuse Box 1
5 MZJ-50A/006 起动继电器 Starting additional relay 1
6 JFZ2904/45A 交流发电机 Alternator 1
7 LED/24V 红 充电指示灯 Battery Charge Indicator 1
8 JK406 预热起动开关 Key switch 1
9 YT-2/0-1.0Mpa 机油压力表 Engine oil pressure gauge 1
10 YT-2/0-3.2Mpa 换档油压表 Trans. oil pressure gauge 1
11 1756ES/24V 停机电磁阀 Shutdown Valve 1
12 DV-2/18-32V 电压表 Voltmeter 1
13 DW-2/40-120ºC 发动机水温表 Coolant Temp. Gauge 1
14 WG-2 发动机水温传感器 Coolant Temp. Sensor 1
15 DW-2/40-140ºC 变矩器油温表 TC. Oil Temp. Gauge 1
16 WG-2 变矩器油温传感器 TC. Oil Temp. Sensor 1
17 DR-2 燃油表 Fuel Gauge 1
18 RG-4/330mm 油位传感器 Fuel level sensor 1
19 WK-3/常闭 手制动灯开关 Hand brake indicator switch 1
20 2.32/24V LED 手制动指示灯 Hand brake indicator 1
21
22 701DN001 工作小时计 Engine hour meter 1
23 JK981-000-3.67 前工作灯开关 Front working lamp SW. 1
24 CG 70W 前工作灯 Front working lamp 2
25 JK981-000-3.67 后工作灯开关 Rear working lamp switch 1
26 CG 70W 后工作灯 Rear working Lamp 2
27 JQ603B 转向灯闪光器 Turn signal flasher 1
28 JK700 转向灯开关 Turn signal switch 1
29 JK981-196-2.4 危险报警灯开关 Hazard warning lamp SW. 1
30 3.2/24V LED 绿 左转向指示灯 Turn left light indicator 1
31 3.3/24V LED 绿 右转向指示灯 Turn right light indicator 1
32 70W/8W/21W 组合前灯 Combination headlamp 2
33 21W/24V 后转向灯 Rear turn lamp 2
34 JK981-090-5114 大小灯开关 Headlamp/side light switch 1
35 2W/24V 仪表内装灯 Instrument panel lamp 6
36 21W+8W/24V 组合后灯 Combination tail lamp 2
37 32-580-042 制动低压开关 Low brake pressure switch 1
38 11.2/24V LED 制动低压指示灯 Low brake pressure indi. 1
39 JN150 制动灯开关 Stop lamp switch 1
40
41 DL-224EG 电喇叭 Electric horn 1
42 电喇叭按钮 Electric horn button 1
43 DZ068/10W 带开关顶灯 Ceiling lamp 1
44 24V/5W 点烟器 Cigarette Lighter 1
45 JK981-045-2.5 前刮水器开关 Front wiper switch 1
46 CG30E-B 前刮水器 Front wiper 1
47 空调开关 Air conditioner SW. 1
48 1Ω+1Ω/100W 调速电阻 Rheostat 2
49 鼓风电机 Evaporator fan motor 1
50 储夜瓶压力开关 Cryogen Pressure SW. 1
51 温控器 Temperature Control 1
52 JQ201S-FLO 40A 空调继电器 Air conditioner relay 1
53 LED/24V 绿 制冷指示灯 Refrigeration Indicator 1
54 冷凝器风扇 Condenser Fan 1
55 SD5H14/24V 压缩机离合器 Compressor Clutch 1
56 JK981-000-3.40 工作警示灯开关 Energy warning lamp SW. 1
57 CG21-10W 工作警示灯 Emergency warning lamp 1
58
59 JK981-045-2.28 后刮水器开关 Rear wiper switch 1
60 CG30E-B 后刮水器 Rear wiper 1
61 JQ603B 倒车闪光器 Back-up lamp flasher 1
62 10W/24V 红色 倒车灯 Back-up lamp 2
63 3T1518 倒车报警器 Back-up buzzer 1
64 JQ201S-PLO 倒车继电器 Back-up lamp relay 1
65 PS61/常开 5bar 倒车压力开关 Back-up pressure switch 1

049 Z35H17T12 空调系统 Air-conditioner System --Chenggong Wheel Loader CG935H Parts Catalogue

序号 代 号 名 称 数量 备注
Item Part No Parts Name Q'ty Remark

1 蒸发器总成 Evaporator Assembly 1
2 三角带A型 Three-cornered Strap 1
3 SD5H14/24V 压缩机 Compressor 1
4 Z35H1701T12 支架总成 Compressor Support 1
5 储液瓶支架 Srorage Bottle Support 1
6 储液瓶 Srorage Bottle 1
7 冷凝器总成 Condenser Assembly 1
8 冷凝器出口胶管 Condenser Outlet Pipe 1
9 高压胶管 High Pressure Pipe 1
10 蒸发器进口胶管 Evaporator Inlet Pipe 1
11 低压管 Low Pressure Pipe 1
12 进水管 Inlet Pipe 1
13 出水管 Outlet Pipe 1
B1 GB5783-86 螺栓M12X30 Bolt M12X30 4
B2 GB848-85 垫圈12 Washer 12 4
B3 GB93-87 垫圈12 Washer 12 4
B4 GB93-87 垫圈6 Washer 6 2
B5 GB848-85 垫圈6 Washer 6 2
B6 GB5783-86 螺栓M6X20 Bolt M6X20 2
B7 GB5783-86 螺栓M8X30 Bolt M8X30 3
B8 GB848-86 垫圈8 Washer 8 3
B9 GB93-87 垫圈8 Washer 8 3